Manitowoc SN12 Specifications download pdf (Page 22)

Maintenance Section 4

4-6

Part Number 000005544 12/09

SANITIZING PROCEDURE

Ice machine sanitizer is used to remove algae or slime. It is not used to remove lime scale or other mineral deposits.

Refer to the “Cleaning Procedure” for removal of lime scale or other mineral deposits.

NOTE: Sanitizing must be performed on adjacent surface areas not contacted by the water distribution system.

Always perform Disassembly for Cleaning and Sanitizing Procedure and a Cleaning Procedure before sanitizing the

ice machine.

Step 1 Turn off the water supply to the ice machine.

Step 2 Place ICE/OFF/CLEAN toggle switch in the

CLEAN position. The dump valve will open and drain the

water from the evaporator and reservoir.

Step 3 Wait approximately 30 seconds (or until the

evaporator is drained) and place the toggle switch in the

OFF position.

Step 4 Refer to the chart and add the correct amount of

sanitizer and cool water for your model ice machine.

Step 5 Remove the top cover from the ice chute and

pour the sanitizer/water solution into the evaporator. Add

the entire amount of premixed solution (excess solution

will exit through the overflow tube in the water reservoir)

Step 6 Replace the ice chute cover and allow the ice

machine to stand for 30 minutes.

Step 7 Turn on the water supply to the ice machine.

Step 8 Move the toggle switch to the ICE position. After

the 15 minute delay period expires the compressor will

energize and produce ice with the sanitizing solution.

Step 9 The ice machine will freeze and discharge the

sanitizing solution into the bin. Allow the cycle to run for

15 minutes.

NOTE: Discard all ice produced during the sanitizing

process.

Step 10 Place the toggle switch in the CLEAN position.

The ice machine will run a wash cycle, a series of rinse

cycles and then stop. This entire cycle lasts

approximately 30 minutes.

Step 11 Refer to Disassembly For Cleaning/Sanitizing,

(Pag 4-7) remove clean and sanitize all parts listed.

Model

Amount of

Sanitizer

Amount of Water

SN12 SN20 2 ounces (60 ml) 3 gallons (11 liters)

ICE

WATER

ICE /

WATER

Add Solution To Evaporator Here

Add Until

Solution Exits

The Water

Reservoir

Overflow Tube

1 2 ... 17 18 19 20 21 22 23 24 25 26 27 ... 31 32

Comments to this Manuals

No comments

Manitowoc SN12 Specifications Page 22

Comments to this Manuals

Related products and manuals for Ice cube makers Manitowoc SN12